RM新时代投资官网_移動混凝土攪拌機動力強勁_行業資訊_自動混凝土攪拌機知識_自動混凝土攪拌機_自動混凝土攪拌車廠家

站內搜索

自動混凝土攪拌機知識

公司新聞行業資訊

熱點

降低自動攪拌車零件磨損需注意的問題！

2021-02-06

混凝土攪拌車油箱氣孔的作用你知道嗎？

2021-03-03

什么是影響自動攪拌機壽命的因素？

2020-12-07

自動混凝土攪拌車運行的幾條秘籍

2021-11-13

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

移動混凝土攪拌機動力強勁

所屬分類：行業資訊發布時間：2022-08-09 來源：http://www.akware.net/ 瀏覽量：0

輪式移動混凝土攪拌機動力強勁混凝土攪拌車裝料前，應先排凈拌筒內殘存的積水和雜物，在運輸過程中要不停的轉動，以防混凝土離析，混凝土攪拌運輸車到達工地和卸料之前。應先使拌筒全速以14—18轉/分轉動1—2分鐘，然后再進行反轉卸料，反轉之前，應使攪拌筒停穩不轉。液壓系統壓力應符合使用說明書中的規定。不得隨意調整，液壓油的油質和油量應符合原定要求。環境溫度高于+25攝氏度，從裝料、運輸、到卸料延續時間不得超過60分鐘。環境溫度低于+25攝氏度，上述時間不得超過90分鐘。冬期施工時，應切實做到：開機前檢查是否結冰，下班時認真排除拌筒內及供水系統內殘存積水。關閉水泵開關，將控制手柄置于“停止”位置。在施工現場卸料完畢后。

The wheeled mobile concrete mixer has strong power. Before loading, the residual water and sundries in the mixing drum shall be drained. It shall be rotated continuously during transportation to prevent concrete segregation. Before the concrete mixer truck arrives at the construction site and discharges the materials. The mixing drum shall be rotated at full speed at 14-18 rpm for 1-2 minutes, and then reversed unloading shall be carried out. Before reversing, the mixing drum shall be stopped stably. The pressure of the hydraulic system shall comply with the provisions in the operating instructions. The oil quality and quantity of hydraulic oil shall meet the original requirements. When the ambient temperature is higher than + 25 ℃, the duration from loading, transportation and unloading shall not exceed 60 minutes. If the ambient temperature is lower than + 25 ℃, the above time shall not exceed 90 minutes. During winter construction, it is necessary to check whether there is ice before starting the machine, and carefully remove the residual water in the mixing drum and the water supply system after work. Turn off the water pump switch and set the control handle to the "stop" position. After unloading at the construction site.

目前國內混凝土施工中主流還是采取塌落度較大的，常見的采用滾筒攪拌機或者臥式攪拌站設備，然而對于干硬性混凝土攪拌應用較少，常規的滾筒式是通過筒壁的轉動帶動混凝土攪拌，對于含水量較低的砼無法勝任，平口攪拌機則是通過立軸帶動圓盤中間的攪拌桿進行轉動，混凝土可攪拌的較為充分。

At present, the mainstream of domestic concrete construction still adopts the equipment with large slump, and the drum mixer or horizontal mixing station is commonly used. However, the dry and hard concrete mixing is rarely used. The conventional drum type drives the concrete mixing through the rotation of the cylinder wall, which is not competent for the concrete with low water content. The flat mouth mixer drives the mixing rod in the middle of the disk through the vertical shaft to rotate, The concrete can be mixed sufficiently.

自走式混凝土攪拌機，它是一款集攪拌和運輸為一體的多功能攪拌機，從而將攪拌、運輸、裝卸集于一身，可攪拌截止類型較為豐富，除了混凝土還可以攪拌飼料、粘稠性物質，干硬性混凝土，工程中的各項任務都可以自身之力獨自完成。

The self-propelled concrete mixer is a multi-functional mixer integrating mixing and transportation, which integrates mixing, transportation and loading and unloading. There are many types of mixing cutoff. Besides concrete, it can also mix feed, viscous substances and dry hard concrete. All tasks in the project can be completed by itself.

平口朝天鍋混凝土攪拌車裝料前，應先排凈拌筒內殘存的積水和雜物，在運輸過程中要不停的轉動，以防混凝土離析，混凝土攪拌運輸車到達工地和卸料之前。應先使拌筒全速以14—18轉/分轉動1—2分鐘，然后再進行反轉卸料，反轉之前，應使攪拌筒停穩不轉。液壓系統壓力應符合使用說明書中的規定。不得隨意調整，液壓油的油質和油量應符合原定要求。環境溫度高于+25攝氏度，從裝料、運輸、到卸料延續時間不得超過60分鐘。環境溫度低于+25攝氏度，上述時間不得超過90分鐘。冬期施工時，應切實做到：開機前檢查是否結冰，下班時認真排除拌筒內及供水系統內殘存積水。關閉水泵開關，將控制手柄置于“停止”位置。在施工現場卸料完畢后。

Before loading the concrete mixer truck with flat mouth facing to the sky, the remaining water and sundries in the mixing drum shall be drained first, and it shall be rotated continuously during transportation to prevent concrete segregation. Before the concrete mixer truck arrives at the construction site and discharges the materials. The mixing drum shall be rotated at full speed at 14-18 rpm for 1-2 minutes, and then reversed unloading shall be carried out. Before reversing, the mixing drum shall be stopped stably. The pressure of the hydraulic system shall comply with the provisions in the operating instructions. The oil quality and quantity of hydraulic oil shall meet the original requirements. When the ambient temperature is higher than + 25 ℃, the duration from loading, transportation and unloading shall not exceed 60 minutes. If the ambient temperature is lower than + 25 ℃, the above time shall not exceed 90 minutes. During winter construction, it is necessary to check whether there is ice before starting the machine, and carefully remove the residual water in the mixing drum and the water supply system after work. Turn off the water pump switch and set the control handle to the "stop" position. After unloading at the construction site.

自上料平口攪拌車是一款集合自動上料、攪拌、卸料、注水為一體的多功能攪拌車，這款平口攪拌車體積較小，靈活的比較高，并且省時間，效率高，投入成本較低。我們生產的自上料平口攪拌車不但能攪拌混凝土，還能攪拌可攪拌塑性、干硬性、流動性混凝土及輕骨料和砂漿，這款自上料平口攪拌車，主要適合空間比較小，路窄，大型攪拌車不容易進入的場合，比如在農村中小工程建設。它不僅是一臺裝載機，也還是一臺罐車，同時還是一臺攪拌車。我們的自上料平口攪拌車采用液壓電子秤，能自動上料上水，并且能準確配比水泥混凝土我們的車還有液壓裝置，結構采用一體設計，在降低勞動力的同時，還可一次性完成上料，攪拌，運輸等多項操作過程，使用范圍也非常廣泛。

The self feeding flat mouth mixer truck is a multi-functional mixer truck integrating automatic feeding, mixing, unloading and water injection. This flat mouth mixer truck is small in size, flexible, time-saving, high in efficiency and low in investment cost. The self feeding flat mouth mixer produced by us can not only mix concrete, but also mix plastic, dry and hard concrete, fluidity concrete, light aggregate and mortar. This self feeding flat mouth mixer is mainly suitable for occasions where the space is small, the road is narrow, and the large mixer is not easy to enter, such as the construction of small and medium-sized projects in rural areas. It is not only a loader, but also a tanker and a mixer. Our self feeding flat mouth mixer truck adopts hydraulic electronic scale, which can automatically feed and water, and can accurately mix cement concrete. Our truck also has hydraulic device, which is designed in one piece. While reducing labor force, it can also complete many operation processes such as feeding, mixing and transportation at one time, and has a very wide range of applications.

以上就是為大家介紹的有關自動混凝土攪拌機的詳細的介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://www.akware.net

The above is the detailed introduction of the automatic concrete mixer for you. I hope it will help you. If you have any questions, please contact us. We will provide you with services with a professional attitude http://www.akware.net

上一頁：混凝土攪拌車施工行車的注意事項下一頁：控制好水泥自上料攪拌機設備用水量的方法

熱門產品 / HOT PRODUCT